Catshaw Mobile DPF Cleaning, South Yorkshire
The workshop in practice moves to your place in Catshaw, and the car sits where it is.
The engineer turns up with the gear in the van and gets to work where the vehicle is. The DPF remains fitted, it's cleaned and regenerated on the car, and once the job's done your vehicle is ready to go. Reckon on roughly two hours. Prices open from £299, and you'll have settled the figure over the phone well before anybody is sent out.
On-site DPF cleaning in Catshaw, stage by stage
Somewhere for the fitted van to sit, plus an engine that will run periodically, is the whole requirement.
Beyond that, it takes the same four steps every time:
- You get a hard figure for the soot level ahead of any cleaning beginning — pulled off the engine ECU by weight and percentage, with sensors and glow plugs looked at while it's connected.
- You can't burn ash out with a regeneration, so the agent goes in through the access point on that vehicle and opens out inside the DPF.
- On the spot is the usual, with a monitored drive around Catshaw available if you want to come along, and the regeneration clears the loosened deposit either way.
- Any fault codes still outstanding get listed at that moment, once the change has been confirmed and the warning light cleared.
Sent over once the second scan is complete, both sets of numbers go into the record.
Locations a DPF cleaning visit can take place round Catshaw
There is no special condition beyond space to park for the duration.
More often than not that amounts to one of these:
- Your own driveway in Catshaw
- The car park at work
- Any spare corner of a forecourt you can use
- Somewhere off Bullhouse Lane with space to park
- For the time you would be waiting anyway, the Tesco customer car park
No standing around with the vehicle, and no DPF being taken from it while you are gone.
Exactly what clogs diesel particulate filters around Catshaw?
Short, cold and stop-start runs are what a DPF manages worst, and a rural hamlet like Catshaw produces little else. Soot that should clear banks up instead, because the filter never sees through a regeneration cycle — not on the run to Millhouse Primary School, not stuck on Catshaw Lane at half past eight, not on ten minutes to Tesco, and not on the hop to Penistone.
Unless you have a standing cause to get out on the M1, under 10 miles from Catshaw, or run over to Sheffield under 15 miles away, full weeks pass without a run of the sort that clears a filter out.
You'll most likely have noticed something already. A whiff of diesel inside, black smoke when you pull away, pull falling off, revs that won't climb, worse consumption, and the stop/start giving up without a word. That builds for a while before the light shows.
On-site DPF cleaning: the problems it answers and the ones it does not
Cleaning cures a unit choked with soot and ash. You should not assume the light means the DPF, and the scan decides the question before any work is done to the motor.
None of the following is cured by treatment:
- Failed sensors reporting a restriction that is not there
- An EGR valve held open
- A fault in the AdBlue system, on the models that use one
- Glow plugs or injectors stopping a regeneration running at all
- A faulty turbo pushing oil through the DPF
Where the fault lies in any of those, we tell you before any job begins rather than after you have paid for it.
A couple more worth noting. Having the filter gutted is not a solution — a vehicle without a serviceable DPF will fail its MOT and driving it is an offence. And the work is sometimes looked up as DPF renewal: nothing is replaced, your original filter is cleaned in place and put back into service.
The free thing to attempt before anything
A DPF only starting to clog will often clear without anyone working on it. Another five more minutes to Millhouse Green and back won't be enough. You want the M1, under 10 miles from Catshaw, held at a steady speed — or the scenic way out to Sheffield.
Once the light's on and you're in limp-home mode, that window has shut and an on-site clean is what's left.
What mobile DPF cleaning comes to around Catshaw
Call-out DPF cleaning opens from £299. You also meet a call-out on each visit. It covers the travelling, the booking, the scan and the advice you are given.
What a particular job works out at turns on the vehicle and on what the unit proves to need, so the price is settled by phone rather than published as a set price. Let us know what you run and roughly whereabouts you are — Catshaw itself, over by Ecklands, or elsewhere in the S postcode area — and you'll be given the price prior to a soul setting off.
You get a 30-day warranty on the work, with aftercare taken care of under it. If that warning light's back inside the period, you'll get an engineer out to Catshaw again.
Whatever you operate, we treat its DPF near Catshaw
The on-site service covers:
- Cars
- Light commercial vehicles and panel vans
- Your HGV lorries
- Site plant and site machinery
- Farm vehicles and machinery
You're not taking anything to us: on all of them the DPF is cleaned in place, at your address over in Catshaw.
You will have to take the other method if the motor will not start at all: the filter comes off, goes to our own workshop by courier, and is cleaned within 24 hours of arrival. We do not detach or refit units for either service.
Zoltan came to our house today to fix our DPF. He arrived promptly, gave us all the information and was absolutely professional and knowledgeable. He was friendly and explained everything he did so we fully understood. He's an asset to your company.
Igor was very professional in both his manner and how he successfully carried out the treatment-I've got my Car back!!
Thank you very much for your service, I would like to say how nice it was to meet Nat and you have an amazing rep in your company very happy with the service i have received.
Where we work around Catshaw and the S area
There's normally a van along Catshaw Lane most weeks, so Catshaw is hardly ever a special trip. The same trip covers Ecklands and Fullshaw, and the smaller places out past Millhouse Green and Crow Edge.
Wider afield across South Yorkshire is nevertheless worth ringing. It's the local diary that decides between today and tomorrow, not the distance — coverage itself reaches across the country.
On-site DPF cleaning across Catshaw: everyday questions
How much time am I without the car?
A couple of hours or so, unless the filter's severely blocked and has to be cleaned twice.
How much is on-site DPF cleaning in Catshaw?
On top of a price opening from £299, the journey, the scan and the advice are met by a call-out charge. The vehicle and your location both shift the number, so we price on the phone.
Do you come to my home or my office?
Right across Catshaw and the wider South Yorkshire area, home or work. Nothing is taken off. Wherever the car happens to be standing is where the work is done.
How fast can an engineer get to me around Catshaw?
What is already booked decides it, but same-day and next-day are the norm. Ring 0303 330 1830 and we'll tell you right away what's open across the S patch.
Is there a fee if it proves not to be the DPF?
Either way that charge holds, since it covers the call-out, the scan and the steer. What you will not get is a bill for cleaning that never happened.
Am I covered if the dash light comes on again?
The 30-day warranty extends to aftercare, and that amounts to a return visit to Catshaw.
How many months before I need it repeated?
That depends on how the car is used afterwards. Short hops round Ecklands and back don't do much. A longer run out past Sheffield, or down the M1, does far more.
Put call-out DPF cleaning booked across Catshaw
Whatever the vehicle is doing, report it to us on 0303 330 1830. Nobody is sent out to Catshaw until the figure is settled and a time is set to suit you. The same people deal with enquiries@dpf-fixer.co.uk in the morning, so nothing sent out of hours is left waiting.
Comprehensive public liability insurance cover is carried by every engineer, and we are SSIP Approved, ISO 9001 certified, ISO 14001 certified and SafeContractor approved.
Mobile DPF Cleaner is a trading name of DPF Fixer Ltd, which is rated 4.5 out of 5 from 1,989 reviews on Trustpilot. The rating is held by DPF Fixer Ltd.