Abbey Mobile DPF Cleaning, Devon
On-site DPF treatment brings the workshop to your place in Abbey.
The engineer turns up with the equipment in the van and gets to work where the motor is. The DPF stays fitted, it's cleaned and regenerated on the motor, and once the job's done your motor is ready to go. It lasts about a couple of hours, starts from £299, and the number is fixed by phone prior to anybody leaving.
Look for this from a DPF cleaning visit across Abbey
All the mobile unit needs is somewhere to sit, and the motor needs a motor that'll turn over at intervals.
Beyond that point, it runs itself:
- Nothing is touched until a full scan has been taken and live readings pulled from the vehicle's ECU, giving the soot load as a percentage and by weight, and checking the sensor readings, the glow plugs and associated components.
- A cleaning fluid is fed in through the entry point on that car and expands inside the DPF, lifting the baked-on soot a regeneration alone will never move.
- A regeneration cycle then clears what the clean has freed, either statically where the car stands or on a monitored run out of Abbey if you want to come along.
- You see the light go out and the difference verified, with whatever is left written down for you.
Both diagnostic reports are forwarded afterwards, so the start and finish figures are on record.
Places a DPF clean can take place around Abbey
Anywhere you can stand it and clear off for the duration.
That takes in most of what people have available:
- A driveway at home in Abbey
- An office car park
- An unused corner of a yard
- A yard off Conigar Lane
- The Waitrose customer car park while you carry on with your day
No waiting with the car, and no filter coming off it while you are gone.
Diesel particulate filters round Abbey, and what blocks them
If you travel around and out of Abbey, a rural hamlet, you're serving the filter exactly the journeys it copes with worst. Look at the week: Hemyock Primary School and back, Shoots Lane at a standstill at half eight, ten minutes at Waitrose, a run to Tiverton Parkway. None of it runs long enough or climbs hot enough to finish a burn cycle, so the unburnt soot just builds up.
Unless you have a standing need to get out on the M5, under 5 miles from Abbey, or head over to Exeter under 25 miles away, full weeks pass without a run of the sort that scours a filter out.
You'll most likely have noticed something already. A whiff of diesel inside, black smoke when you put your foot down, power falling off, revs that won't climb, worse consumption, and the stop/start giving up without a word. That builds for a while before the light shows.
What mobile DPF cleaning answers, and what it does not
A blocked unit is what treatment fixes. The scan separates that from everything else that puts the same light on a dashboard, and it runs before a thing is touched to the car.
Not one of the following is cured by a clean:
- A sensor reporting a restriction that is not real
- A stuck-open EGR valve
- An AdBlue problem
- Plugs or injectors stopping a regeneration from starting at all
- A turbo failure putting oil through the unit
If it proves to be any of those, you'll hear it prior to any job starting — not once you've handed over.
Driving without a working DPF is an offence and the vehicle will not get through an MOT, so having the unit gutted solves nothing. Nor is anything exchanged: what people type in as DPF renewal is the same filter, cleared where it sits and put back to work.
The cheapest thing to start with before anything
A DPF only just starting to load up will often clear without anyone touching it. Five more minutes to Dunkeswell and back won't do it. You need the M5, under 5 miles from Abbey, held at a constant speed — or the scenic way round to Exeter.
Once the light is on and the car has dropped into limp mode, that window has gone and an on-site clean is the obvious next move.
What call-out DPF cleaning comes to across Abbey
On-site DPF regeneration starts from £299. A call-out charge covers every visit, paying for the call-out, the booking, the diagnostic and the advice that comes with it.
You'll have the number by phone rather than off a list, because the car and the state of the unit both change it. Abbey itself, across at Mackham, or the far side of the EX postcode area — where you live feeds in, and so does the vehicle. Both are fixed before anyone sets off.
You get a 30-day warranty on the work, with aftercare included under it. An engineer drives back to Abbey should the DPF light reappear during that period.
Vehicles we clean DPFs on near Abbey
The same on-site work takes in:
- Cars and estates
- Panel vans and light commercials
- Heavy vehicles
- Site plant and building machinery
- Agricultural plant
The DPF is cleared in place on every one, at your address over in Abbey rather than at our premises.
You will have to take the other route if the vehicle will not turn over at all: the filter comes off, is taken to our own workshop by carrier, and is treated within a day of reaching us. Neither route includes taking a unit off or refitting one.
"They consistently delivered high-quality work, showing strong attention to detail and professionalism in every task. I would highly recommend them for any role requiring reliability, expertise, and a strong work ethic. ".
Needed the van urgently for work, they came first thing the next day, ran a full test before and found it didn't need a clean but was the temp sensors that have failed, gave some good advise and left. Quick, pleasant and honest to deal with.
Good service! They cleaned up my DPF and fault diagnosed 2 other issues. I went and ordered a new glow plug relay and air mass sensor. Replaced on arrival. cleared the faults with an OBD and voila! All lights out and my van now runs like a stallion! Happy days.
Abbey and the EX area
There's generally a van on Shoots Lane most weeks, so Abbey is hardly ever a detour. The same trip includes Mackham and Hemyock, and the villages out past Dunkeswell and Sheldon.
Wider afield across Devon, the call is nonetheless worth placing. You are not waiting on the journey. Coverage extends across the country, and it is the local schedule that settles whether it is today or tomorrow.
What Abbey owners ask about on-site DPF cleaning
How much time does a mobile DPF clean need?
Around a couple of hours. A badly clogged unit can need a repeat clean, which extends that.
What does call-out DPF cleaning cost around Abbey?
It begins from £299, and there's a call-out on top taking in the journey, the check and the advice. The vehicle and your location both move the number, so we cost it by phone.
Where do you in fact do the job?
Either suits: your home or your workplace, anywhere in Abbey or the wider Devon area. Treatment happens on the car, where it sits, and the filter is never taken off.
How soon can you get to Abbey?
According to the week's workload, the same day or the next is the typical answer. What is available across the EX patch is something we can tell you the moment you ring 0303 330 1830.
Do I still pay if you are unable to clean it?
The call-out charge stands either way, because the visit, the check and the guidance have all been done. No charge is made for work that was not done.
The DPF dash light returns — what then?
An engineer drives back to Abbey. Aftercare of that type is what the 30-day warranty covers.
After the cleaning, how long will it hold up?
How the vehicle is used afterwards governs that. Out past Exeter, or down the M5, is worth far more to the unit than short hops round Mackham and back.
Put on-site DPF cleaning in the diary across Abbey
A phone call to 0303 330 1830 and an explanation of the fault is all it needs. Not a soul is sent out to Abbey until the figure is fixed and a time is booked to suit you. If the phones are shut, email enquiries@dpf-fixer.co.uk — the same office answers it in the morning.
SSIP Approved, SafeContractor approved, ISO 9001 certified and ISO 14001 certified — and our team hold full public liability insurance cover on top of it.
Mobile DPF Cleaner is a trading name of DPF Fixer Ltd, which is rated 4.5 out of 5 from 1,989 reviews on Trustpilot. The rating is held by DPF Fixer Ltd.